Removal of phenols and methane production with coffee processing wastewater supplemented with phosphorous

详细信息    查看全文

• 作者：A. C. Villa-Montoya ; M. I. T. Ferro…
• 关键词：Acidified reactor recuperation ; Organic loading rate increase ; Removal of toxics ; SBR post ; treatment ; Wet processing of coffee fruits
• 刊名：International Journal of Environmental Science and Technology
• 出版年：2017
• 出版时间：January 2017
• 年：2017
• 卷：14
• 期：1
• 页码：61-74
• 全文大小：
• 刊物主题：Environment, general; Environmental Science and Engineering; Environmental Chemistry; Waste Water Technology / Water Pollution Control / Water Management / Aquatic Pollution; Soil Science & Conservati
• 出版者：Springer Berlin Heidelberg
• ISSN：1735-2630
• 卷排序：14

文摘

This manuscript addresses the evaluation of the methane production and removal of organic matter and phenols from coffee fruits processing wastewater (CPW). The systems consisted of two serial upflow anaerobic sludge blankets (UASB1 and UASB2) and one sequential batch reactor (SBR). The organic loading rate (OLR) was increased from 3 to 6 g COD/L.d, and the hydraulic retention times (HRT) applied to UASB1, UASB2 and SBR were 60, 30 and 75 h, respectively. Similar OLRs were tested with raw CPW (tests 1 and 2) and CPW after the addition of Simple Super Phosphate (SSP) (tests 3 and 4). The COD removals in the two stages UASB + SBR were approximately 85 % in tests 1 and 3 and 88 % in tests 2 and 4. The total phenols (TF) removal ranged between 70 and 92 %. The highest bioenergy productivities were achieved in UASB1, i.e., approximately 0.33 and 0.70 L CH₄/L.d with OLR of approximately 3 and 6 g COD/L.d. Although, the addition of SSP did not induce a superior methane production or TF removal, it promoted enabled a faster biomass growth after acidification time. SBR was tested with two cycles—cycle 1 with anaerobic + aerobic reactions (tests 1 and 2) and cycle 2 with anaerobic + aerobic + anaerobic reactions and lower sedimentation time (tests 3 and 4). Cycle 2 obtained higher COD and TF removal. The addition of SSP enhanced the SBR performance and increased between 13 and 24 % the TF removal.