顶空固相微萃取-气质联用分析香荚兰浸膏风味组分的条件优化

详细信息    查看全文 | 推荐本文 |

英文篇名：Optimization of Flavor Components of Vanilla Concentrate by Headspace Solid Phase Microextraction-GC Mass Spectrometry Analysis 作者：徐飞 ; 李俄艳 ; 初众 ; 张彦军 ; 朱科学 ; 曲鹏 英文作者：XU Fei;LI Eyan;CHU Zhong;ZHANG Yanjun;ZHU Kexue;QU Peng;Spice and Beverage Research Institute, Chinese Academy of Tropical Agricultural Sciences;National Center of Important Tropical Crops Engineering and Technology Research;Hainan Provincial Engineering Research Center of Tropical Spice and Beverage Crops;Cropical Crop College, Yunnan Agricultural University; 关键词：顶空固相微萃取 ; 气相色谱-质谱 ; 香荚兰浸膏 ; 风味组分 英文关键词：headspace solid phase microextraction (HS-SPME);;gas chromatography-mass spectrometry (GC-MS);;vanilla concentrate;;flavor components 中文刊名：RDZX 英文刊名：Chinese Journal of Tropical Crops 机构：中国热带农业科学院香料饮料研究所;国家重要热带作物工程技术研究中心;海南省热带香料饮料作物工程技术研究中心;云南农业大学热带作物学院; 出版日期：2019-02-25 出版单位：热带作物学报 年：2019 期：v.40 基金：中国热带农业科学院基本科研业务费专项资金(No.1630142017019,No.1630142017020) 语种：中文; 页：RDZX201902019 页数：11 CN：02 ISSN：46-1019/S 分类号：146-156

摘要

为选择适宜的香荚兰浸膏萃取条件,采用顶空固相微萃取-气相色谱-质谱联用技术,以固相微萃取样品处理量、萃取温度和萃取时间三个条件分析各萃取条件对香荚兰浸膏风味组分、面积及含量的影响。结果表明:在实验范围内香荚兰浸膏最佳萃取条件为萃取样品添加量2.0 g、萃取温度80℃、萃取时间25 min。最佳条件下香荚兰浸膏鉴定出匹配度90以上的化合物45种,此条件下总化合物面积(×10~(11))及香兰素面积(×10~(10))最高分别为1.04±0.09、6.99±0.46,匹配度90以上化合物占总化合物相对百分含量的90.24%;香荚兰中主要化合物醛类百分含量占总化合物相对百分含量的72.03%。
        In order to select suitable extraction conditions of vanilla concentrate, the influence of each extraction condition(extraction sample quantity, extraction temperature and extraction time) on flavor composition, area and content of vanilla concentrate was analyzed using the headspace solid-phase microextraction(HS-SPME) and gas chromatography-mass spectrometry(GC-MS) technology. The results showed that the optimum extraction conditions were extracting samples of 2.0 g, extractive temperature of 80 ℃, time of 25 min in the experimental range. Under the best conditions, 45 compounds were identified with a matching degree of more than 90 the total compound area(×10~(11))and the largest area of vanillin(×10~(10)) was 1.04±0.09, 6.99±0.46, repectively. The percentage of compounds in the main compounds was 90.24% with a matching degree of more than 90. The aldehydes content in the main compounds also reached 72.03% in vanilla.

引文

[1]宋应辉,王庆煌,赵建平,等.香草兰产业化综合技术研究[J].热带农业科学,2006,26(6):43-46.
    [2]Gonzalez-Arnao M T,Lazaro-Vallejo C E,Engelmann F,et al.Multiplication and cryopreservation of vanilla(Vanilla planifolia‘Andrews’)[J].In Vitro Cellular&Developmental Biology-Plant,2009,45(5):574-582.
    [3]Menon S,Nayeem N.Vanilla planifolia:A review of a plant commonly used as flavouring agent[J].International Journal of Pharmaceutical Sciences Review&Research,2013,20(2):225-228.
    [4]Gu F,Xu F,Tan L,et al.Optimization of enzymatic process for vanillin extraction using response surface methodology[J].Molecules,2012,17(8):8753.
    [5]徐飞,李娜,初众,等.香荚兰浸膏精制工艺优化及挥发性成分分析[J].食品科学,2018,39(4):188-193.
    [6]程晓雪.麻杏竺胆颗粒提取工艺的研究[J].当代医药论丛,2018,16(2):154-155.
    [7]邵雪庆,唐晓萌,杨盟,等.愈肠颗粒的提取工艺研究[J].药学实践杂志,2018(1):46-49.
    [8]陈汝玲,吴江顺,吴静澜,等.紫金抗病毒中药唇膏的提取[J].现代医学与健康研究电子杂志,2018,2(1):130-131.
    [9]师苑,朱红薇,张运洋,等.桦褐孔菌不同提取物提取工艺及生物活性研究[J].广州化工,2018,46(7):67-69.
    [10]郭永来,张静菊,刘泗明.超临界二氧化碳萃取玫瑰浸膏的研究[J].香料香精化妆品,2018(1):17-19.
    [11]张静姝,刘春叶,靖会,等.酸枣仁皂苷的不同提取与纯化工艺对比研究[J].应用化工,2018,47(1):56-58.
    [12]李艳萍,李海燕,纪晓婉,等.金钗石斛叶中总黄酮的提取分离及体外抗阿尔茨海默病活性研究[J].中国药房,2018,29(3):330-333.
    [13]张玲,张云飞,李春海,等.菠萝蜜芳香浸膏提取工艺及挥发性成分分析[J].食品研究与开发,2018,39(3):41-48.
    [14]孙铭忆,李冰韶,王永洁,等.基于模糊层次分析法优选复方黄芪水浸膏提取工艺路线[J].中草药,2018,49(2):325-329.
    [15]关体青,张博,张丽,等.秘鲁浸膏热裂解产物分析研究[J].轻工科技,2018,34(2):5-6.
    [16]董智哲,谷风林,徐飞,等.固相微萃取和同时蒸馏萃取法分析海南香草兰挥发性成分[J].食品科学,2014,35(2):158-163.
    [17]董智哲.香草兰挥发性成分鉴定及提取研究[D].武汉:华中农业大学,2014.
    [18]谷风林,董智哲,徐飞,等.利用SPME-GC×GC/TOF-MS对香草兰中挥发、半挥发性成分萃取与分析研究[J].热带作物学报,2015,36(1):185-191.